Yamaha rx v396 rds

Page 1

AV RECEIVER
X-V396/RX-V396RDS

HTR-5230/HTR-523ORDS

SERVICE MANUAL

IMPORTANT NOTICE

This manual has been provided for [he use of authorized YAMAHA Retailers and their service personnel.
It has been assumed Ihal basic service procedures inhereni lo the indu sIry. and more specifically YAMAHA
Products, are already known and underslood by Ihe users, and have lherefnre nor been resKaIed.

WARNING: Failure to follow appropriate service and safety procedures when servicing this product
may result in personal injury, destruction of expensive components. and failure of the
product to perform as specified. For these reasons, we advise all YAMAHA product
owners that any service required should be performed by an authorized YAMAHA
Retailer or the appointed service representative.

IMPORTANT: The presentation or sale of this manual to any individual of firm does not constitute
authorization, certification or recognition of any applicable technical capabilities,
or establish a principlerageni relationship of any form.

The data provided is believed to be accurate and applicable to the unil(s) indicated on the cover. The research,
engineering, and service departments of YAMAHA are continually striving to improve YAMAHA products.
Modifications are. therefore, inevitable and specifications are subject to change without notice or obligation
to retrofit. Should any discrepancy appear to exist, please contact the distributors Service Division.

WARNING: Static discharges can destroy expensive components. Discharge any static electricity
your body may have accumulated by grounding yourselfto the ground buss in the unit
(heavy gauge black wires connect to this buss).

IMPORTANT: Turn the unit OFF during disassenibly and part replacement. Recheck all work before
you apply power to the unit.

I CONTENTS

TO SERVICE PERSONNEL 1 AMP ADJUSTMENT 21

REMOTE CONTROL PANELS 1
FRONT PANELS 2
REAR PANELS 3~4
SPECIFICATIONS 5~6
INTERNAL VIEW 7
DISASSEMBLY PROCEDURES 7
SELF DIAGNOSIS FUNCTION 8~19
FACTORY PRESET 20

:mvitxv:17wi;r 13777§§Em§$fiflfifi LYvETs
This Service Manual uses recycled paper

TUNER ADJUSTMENT 22~25
IC DATA 26~34
DISPLAY DATA 35
BLOCK DIAGRAM . . 36~39
PRINTED CIRCUIT BOARD 40~59
SCHEMATIC DIAGRAM 60~67
PARTS LIST 68~85
REMOTE CONTROL TRANSMITTER 86~88

.YAMAHA

YAMAHA CORPORATION
O..Box1 Hamamaisu. Japan

Page 2

RX-V396/RX-V396RDS/HTR-5230/HTR-523ORDS

I TO SERVICE PERSONNEL

1. Critical Components information
Components having special characteristics are marked A and must be
replaced with parts having specifications equal to those originally

installed AC LEAKAGE
WALL EQUIPMENT TESTER OR
2. Leakage Current Measurement (For 120V Model only) OUTLET UNDER TEST EQUIVALENT

When service has been completed, it is imperative that you verify that

all exposed conductive surfaces are properly insulated from supply (H) D- -
circuits. J.-
0 Meter impedance should be equivalent to 1500 ohm shunted by 0.15th _
O Leakage current must not exceed 0.5mA. -
0 Be sure to test for leakage with the AC plug in both polarities INS-IEfléT-ENG

"CAUTION"

"F804: FOR CONTINUED PROTECTION AGAINST RISK OF FIRE,REPLACE ONLY WITH SAME TYPE 6.0A,125V FUSE."
E
J 7,, ATTENTION
F804: UTILISER UN FUSIBLE DE RECHANGE DE MEME TYPE DE 6.0A, 125v FUSE

WARNING: CHEMICAL CONTENT NOTICE!

The solder used in the production of this product contains LEAD. In addition, other electrical/electronic and/or plastic (where
applicable) components may also contain traces of chemicals found by the California Health and Welfare Agency (and possibly
other entities) to cause cancer and/or birth defects or other reproductive harm.

DO NOT PLACE SOLDER, ELECTRICAL/ELECTRONIC OR PLASTIC COMPONENTS IN YOUR MOUTH FOR ANY REASON
WHATSOEVER!

Avoid prolonged, unprotected contact between solder and your skin! When soldering, do not inhale solder fumes or expose eyes
to solder/flux vapor!

If you come in contact with solder or components located inside the enclosure of this product, wash your hands before handling
food.

I REMOTE CONTROL PANELS

V U,C,R,T and A models 0 V B and G models Ems

eeo
,eoe
Ea

m WWW Em, :1
® ® 7, E, a)

U
D
U

2
,
Fl
3

§

3
a
E

0:6)
6)

g
3l

536
El
HE
E)

fi®®®
g

@YAMAHA
\_/

@VAIMHA

an: m