Sony cdp x 333 es service manual

Page 1

CDP-X333ES A

SERVICE MANUAL

Canadian Model
AEP Model
UK Model

SPEC'F'CAT'ONS Model Name Using Similar Mechanism CDP-XSSSES
Compact disc player CD Transport Mechanism Type CDM11H-6C
Frequency response 2 Hz - 20 kHz «:03 dB Optical Pick-Up Block Type BU-6C
Signal to noise ratio More than 115 dB
Dynamic range More than 100 dB Power 23 W
Harmonic distortion Less than 0.0018% consumption
. Dimensions 430x125X375 mm (w/h/d)
Ch I t M th 110 dB
anne separa ten are an (approx, including (17X5X14 7/, inches)
Outputs projections)
LINE OUT Output level 2 v (at so kiloohms) we'gh (approx-l 07 k9 23 5 0 °Z)_
(FlXED) Load impedance over 10 kiloohms M05 0 0m mm
(phonojacks) 11kg(24|bs§oz)
LINE OUT Oulpul level max. 2 v (a! so kiloohms) Rem? C°mmandef RM'D991 .
(VARIABLE) Load impedance over 50 kiloohms Remote control Infrared control
(phone jacks) system
DlGlTAL OUT Wave length 560 nm Power 3 V DC with two batteries size AA
(OPTICAL) (optical Output level -18 dBm requirements (IEO designation R6)
pm conned) Dimensions sleexi 75 mm (wlh/d)
HEADPHONES Output level max. 28 mW (2 1/2x23/32x7 inches)
' 32 h s
{asctgeo phone Load impedance 0 in Weight 130 9 (46 02)
Including batteries
General Supplied accessories
Power AEP model: Connecting cord 1
requirements 220-230V AC, 50/60Hz (2 phone plugs ~ 2 phone plugs) t
UK model: R t 1
240v AC, 50/60Hz em" 9 d
Canadian model: comman er
120V AC, 60Hz R6 (size AA) 2
batteries

l.-
MlCBOflUlll

Design and specifications subject to change without notice.

CflMPACT DISC PLAYER

SONY; ;

Page 2

CDP-X333ES

TABLE OF CONTENTS

Section Title fgge
1. GENERAL ............................................................ 4
2. ELECTRICAL BLOCK CHECKING ~~~~~~~~~~~~~~~~~~~~~~~~~~ 5
3. DIAGRAMS

34' Block Diagram ...................................................... 6
3-2. Semiconductor Lead Layouts -~9
3-3, Circuit Boards Location -------

3-4. Printed Wiring Boards ------------------

3-5. Schematic Diagram --------------------

4. EXPLODED VIEWS

4-1, Cabinet Section 20
4-2. Front Panel Assy N 21
4-3. Chassis Assy """"" ---22
44. Mechanism Block -- ~--23
4_54 Base Unit ............................................................ 24
5. ELECTRICAL PARTS LIST ------------------------------- 25

SAFETYARELATED COMPONENT WARNINGII

COMPONENTS IDENTIFIED BY MARK A OR DOTTED
LINE WITH MARK A ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB-
LISHED BY SONY.

ATTENTION AU COMPOSANT AVANT RAPPORT

A LA sécum'ré!

LES COMPOSANTS IDENTIFIES FAR UNE MARQUE Q
SUR LES DIAGRAMMES SCHEMATIQUES ET LA LISTE
DES PIECES SONT CRITIQUES POUR LA SECURITE

DE

FONCTIONNEMENT. NE REMPLACER CES COM<

POSANTS OUE PAR DES PIECES SONY DONT LES
NUMEROS SONT'DONNES DANS CE MANUEL 0U
DANS LES SUPPLEMENTS PUBLIES PAR SONY.

For the European Countries

This Compact Disc player

cuss LASER PRODUCT is classified as a CLASS 1
wow LASERWTE LASER Product.

KlASS l LASERAPPARAT The CLASS 1 LASER
PRODUCT label is located

on the rear exterior.

NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK 0R BASE UNIT

The laser diode in the optical pick-up block may suffer
electrostatic breakdown because of the potential di-
ference generated by the charged electrostatic load,
etc. on clothing and the human body.

During repair, pay attention to electrostatic break-
dowu and also use the procedure in the printed matter
which is included in the repair parts.

The flexible board is easily damaged and should be
handled with care,

NOTES ON LASER DIODE EMISSION CHECK

The laser beam on this model is concentrated so as to
be focused on the disc reflective surface by the objeo
tive lens in the optical pick-up block. Therefore, when
checking the laser diode emission, observe from more
than 30cm away from the objective lens.

MODEL IDENTIFICATION
-Model Number Label-

SONYa MODEL No. coexssazs

COMPACT DISC PLAYER

Canadian Model : AC: 120V 60Hz 23W
AEP Model : AC: 220-230V~50/60Hz
UK Model : AC: 240V~50l60Hz